DOI : https://doi.org/10.18517/ijaseit.12.5.13750

Potential Use of Cross-flow Microfiltration System in Separation of Functional Compound from Fermented Beetroot (Beta vulgaris L.) as Natural Oxidation Prevention

Agustine Susilowati (1), - Aspiyanto (2), Yati Maryati (3), Hakiki Melanie (4)
(1) Research Center for Chemistry, National Research and Innovation Agency (BRIN), PUSPIPTEK Serpong, South Tangerang, Banten, Indonesia
(2) Research Center for Chemistry, National Research and Innovation Agency (BRIN), PUSPIPTEK Serpong, South Tangerang, Banten, Indonesia
(3) Research Center for Chemistry, National Research and Innovation Agency (BRIN), PUSPIPTEK Serpong, South Tangerang, Banten, Indonesia
(4) Research Center for Chemistry, National Research and Innovation Agency (BRIN), PUSPIPTEK Serpong, South Tangerang, Banten, Indonesia
Fulltext View | Download
How to cite (IJASEIT) :
Susilowati, Agustine, et al. “Potential Use of Cross-Flow Microfiltration System in Separation of Functional Compound from Fermented Beetroot (Beta Vulgaris L.) As Natural Oxidation Prevention”. International Journal on Advanced Science, Engineering and Information Technology, vol. 12, no. 5, Sept. 2022, pp. 1736-43, doi:10.18517/ijaseit.12.5.13750.
Citation Format :
This study was conducted to determine the potential utilization of microfiltration (MF) membrane in separating functional compounds from beetroot (Beta vulgaris L.) biomass as a functional drink for natural oxidation prevention. Separation was performed through MF membrane (pore size of 0.15 µm) at room temperature, flow rate ~7.5 L/min, and TMP 2 and 6 bar for 0, 5, 15, 25, and 35 minutes. The results showed that process optimization based on gallic acid as total polyphenols and acetic acid were achieved at TMP 2 and 6 bar for 35 minutes, respectively. At TMP 2 and 6 bar produced retentate with acetic acids 1.24 and 0.95%, gallic acid 0.42 and 0.41%, total solids 3.49 and 3.47%, total sugars 36.64 and 44.66 mg/mL, pH 3.11 and 3.10, and inhibiting ability of 62.45 and 58.48%, respectively, meanwhile permeate had acetic acid 0.73 and 0.82%, gallic acid 0.31 and 0.33%, total solids 3.39 and 3.38%, total sugars 40.95 and 61.56 mg/mL, pH 3.12 and 3.13, inhibiting ability of 47.62 and 52.43%, respectively. In these conditions, CF-MF is technically able to retain acetic acid (2.63-folds) and gallic acid (1.21-folds) in the retentate and increase inhibition by 25.12 and 11.25% in comparison with the initial process (0 minutes). The LC-MS analysis of permeate at TMP 2 and 6 bar for 35 minutes were predominated by monomers of acetic acid and gallic acid with MW 61.2450 Da. (M+) and 193.0327 Da. (M+Na+) and relative intensities 100 %.

A. Susilowati, Aspiyanto, P. D. Lotulung, Y. Maryati, and H. Mulyani, “Recovering organic acids fermented beetroot (Beta vulgaris L.) through microfiltration to prevent increase of natural cholesterol,” in AIP Conference Proceedings, 2019, vol. 2175.

H. Mulyani, Y. Maryati, E. Filailla, A. Susilowati, P. D. N. Lotulung, and A. Aspiyanto, “Benefits of fermented beet (Beta vulgaris L.) against digestive infection Escherichia coli and free radicals prevention,” in AIP Conference Proceedings, 2019, vol. 2175.

B. Kaurinovic and D. Vastag, “Flavonoids and phenolic acids as potential natural antioxidants,” in Antioxidants, IntechOpen London, UK, 2019, pp. 1-20.

J. Kruk, H. Y. Aboul-Enein, A. KÅ‚adna, and J. E. Bowser, “Oxidative stress in biological systems and its relation with pathophysiological functions: the effect of physical activity on cellular redox homeostasis,” Free Radic. Res., vol. 53, no. 5, pp. 497-521, 2019.

J. Quero, I. Mí¡rmol, E. Cerrada, and M. J. Rodrí­guez-Yoldi, “Insight into the potential application of polyphenol-rich dietary intervention in degenerative disease management,” Food Funct., vol. 11, no. 4, pp. 2805-2825, 2020.

Y. Zhao et al., “Vinegars but not acetic acid are effective in reducing plasma cholesterol in hamsters fed a high-cholesterol diet,” Food Funct., vol. 11, no. 3, pp. 2163-2172, 2020.

W. J. Hurst, J. W. Finley, and J. M. deMan, “Additives and contaminants,” in Principles of Food Chemistry, Springer, 2018, pp. 527-565.

P. Garcí­a-Pí©rez, S. Losada-Barreiro, P. P. Gallego, and C. Bravo-Dí­az, “Adsorption of gallic acid, propyl gallate and polyphenols from Bryophyllum extracts on activated carbon,” Sci. Rep., vol. 9, no. 1, pp. 1-9, 2019.

M. Govea-Salas et al., “Gallic Acid as a Putative Antioxidant in Usage Against Liver Disease,” in The Liver, Elsevier, 2018, pp. 317-322.

R. M. Paixí£o et al., “Discolouration of contaminated water with textile dye through a combined coagulation/flocculation and membrane separation process with different natural coagulants extracted from Moringa oleifera Lam. seeds,” Can. J. Chem. Eng.

T. UroÅ¡ević, D. Povrenović, P. Vukosavljević, I. UroÅ¡ević, and S. Stevanović, “Recent developments in microfiltration and ultrafiltration of fruit juices,” Food Bioprod. Process., vol. 106, pp. 147-161, 2017.

K. L. Jepsen, M. V. Bram, S. Pedersen, and Z. Yang, “Membrane fouling for produced water treatment: A review study from a process control perspective,” water, vol. 10, no. 7, p. 847, 2018.

K. Dewettinck, T. T. Le, and V. B. Nguyen, “Membrane separations,” in Alternatives to Conventional Food Processing, Royal Society of Chemistry, 2018, pp. 418-498.

J. L. Lippens et al., “Rapid LC-MS Method for Accurate Molecular Weight Determination of Membrane and Hydrophobic Proteins,” Anal. Chem., vol. 90, no. 22, pp. 13616-13623, 2018.

A. Cassano, A. Bentivenga, C. Conidi, F. Galiano, O. Saoncella, and A. Figoli, “Membrane-based clarification and fractionation of red wine lees aqueous extracts,” Polymers (Basel)., vol. 11, no. 7, p. 1089, 2019.

L. Pola, S. Collado, P. Oulego, P. í. Calvo, and M. Dí­az, “Characterisation of the wet oxidation of black liquor for its integration in Kraft paper mills,” Chem. Eng. J., vol. 405, p. 126610, 2021.

T. Tran, C. Grandvalet, F. Verdier, A. Martin, H. Alexandre, and R. Tourdot-Marí©chal, “Microbial Dynamics between Yeasts and Acetic Acid Bacteria in Kombucha: Impacts on the Chemical Composition of the Beverage,” Foods, vol. 9, no. 7, p. 963, 2020.

K. Jakubczyk, J. KaÅ‚duÅ„ska, J. Kochman, and K. Janda, “Chemical profile and antioxidant activity of the kombucha beverage derived from white, green, black and red tea,” Antioxidants, vol. 9, no. 5, p. 447, 2020.

A. Kotani, F. Kusu, K. Takamura, and H. Hakamata, “A Portable Voltammetric Sensor for Determining Titratable Acidity in Foods and Beverages,” J. Electrochem. Soc., vol. 167, no. 3, p. 37517, 2019.

R. Chen et al., “Fouling behaviour of soluble microbial products and extracellular polymeric substances in a submerged anaerobic membrane bioreactor treating low-strength wastewater at room temperature,” J. Memb. Sci., vol. 531, pp. 1-9, 2017.

M. Serajuddin, M. A. I. Chowdhury, M. M. Haque, and M. E. Haque, “Using Turbidity to Determine Total Suspended Solids in an Urban Stream: A Case Study,” in Proceedings of the 2nd International Conference on Water and Environmental Engineering, Dhaka, 2019, pp. 19-22.

A. Gul, J. Hruza, and F. Yalcinkaya, “Fouling and Chemical Cleaning of Microfiltration Membranes: A Mini-Review,” Polymers (Basel)., vol. 13, no. 6, p. 846, 2021.

Authors who publish with this journal agree to the following terms:

    1. Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
    2. Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
    3. Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).